Mercedes GL550 X166 Reliability: The Cylinder Scoring Risk
Common Failure Points & Costs
| Component | Failure Mileage | Symptom | Est. Cost (USD) | Risk Level |
|---|---|---|---|---|
| Cylinder Wall Scoring | 80k - 120k miles | Knocking, heavy oil usage | $15,000+ (Engine Replacement) | Critical |
| AirMatic Suspension (4-Corner) | 60k - 90k miles | Exploding air bags | $2,000 - $4,000 | High |
| Camshaft Sensors (Oil Wicking) | Any | Oil in harness, ECU damage | $300 - $800 | Critical |
| Transfer Case Chain | 100k+ miles | Clicking/popping on turns | $2,500 - $4,000 | Medium |
| Active Curve System | 80k - 120k miles | Leaking hydraulic fluid | $2,000 - $5,000 | Medium |
Reliability Verdict
The GL550 is the highest-risk application of the M278 engine. The vehicle's weight puts immense thermal load on the cylinders, leading to a higher rate of Silitec wall scoring than in sedans.
Mercedes GL550 (X166) Reliability: Heavy is the Head
The Mercedes GL550 (X166) is a 5,500-lb luxury fortress. It seats 7 adults, tows 7,500 lbs, and hits 60 mph in 5.3 seconds.
But that weight comes at a cost. The GL550 is arguably the least reliable application of the M278 V8 engine.
1. The Critical Risk: Cylinder Scoring
Why does the GL550 suffer from cylinder scoring (Silitec failure) more than the S550?
- Physics: The engine works significantly harder to move the GL’s mass.
- Heat: Higher loads = higher cylinder temperatures = failures of the oil film.
- Result: The piston skirt scuffs the cylinder wall.
- The Sound: A hollow “thock-thock” knock at idle.
- The Fix: There is no fix. You need a new engine ($15,000).
[!CAUTION] BORESCOPE REQUIRED Never buy a GL550/GLS550 without inspecting the cylinder walls with a camera.
2. AirMatic: Working Overtime
The AirMatic suspension on the GL550 carries massive loads.
- Front Struts: Fail around 60k-80k miles.
- Rear Bags: Can actually explode (loud bang) if pushed too far past their service life.
- Compressor: Burns out trying to compensate for leaks.
3. Active Curve System (Optional)
Many GL550s have the Active Curve System (hydraulic sway bars).
- Failure: The hydraulic reservoir leaks or the valve block fails.
- Cost: Parts are extremely expensive. A leak can cost $3,000 to chase down.
4. Maintenance Comparison (GL550 vs GLS450)
Is the V8 worth it over the V6?
| Feature | GL550 (M278 V8) | GL450 (M276 V6) |
|---|---|---|
| Power | 429 HP | 362 HP |
| Scoring Risk | High | Low |
| Tire Life | 15k - 20k miles | 25k - 30k miles |
| Brakes | $1,500 (Massive Rotors) | $900 |
| Real MPG | 12 City | 16 City |
5. Verdict
The GL550 is a supercar disguised as a school bus. It is magnificent to drive, but it requires a “supercar budget” to maintain. For most families, the GL450 is the smarter buy—it lacks the V8 torque, but it likely won’t require a $15,000 engine replacement.
Related:
Expert Buying Advice
Do not buy a GL550 without a borescope inspection of the cylinders. The risk of scoring is real. Ensure AirMatic shocks have been replaced. Consider the GL450 (V6) for lower risk.